Hydrogen generators

AGS Engineering designs and manufactures hydrogen electrolysis stations
Performance up 170 nm3/hour
Clean up 99,9998 %
1
1
Wide range of hydrogen generators in performance 0,66 – 170 nm3/h Allows you to choose the optimal solution for production without overpaying for excess cubic meters of gas
1
Hydrogen concentration up to 99,9998% The electrochemical method allows to obtain high purity hydrogen up to 99.9%, then, to achieve a hydrogen concentration of 99.9998%, small oxygen impurities are removed by catalytic afterburning on a palladium catalyst in a DEOXO column
1
Hydrogen pressure up to 30 BAR The design features of hydrogen generators and the flexibility of the process make it possible to produce hydrogen directly under pressure from 4 to 30 bar, without the use of expensive booster units
1
Hydrogen dew point temperature up to -75°С The drying system integrated in the technological unit, consisting of two columns, in which the alternating process of drying and regeneration takes place, allows to obtain a hydrogen dew point up to -60°C or optionally up to -75°C
The source of hydrogen and oxygen in electrolysis units is demineralized and deeply purified water. The life of the entire hydrogen generation system depends on the quality of the water treatment. The salts contained in untreated industrial water very quickly destroy the electrodes in the electrolyzer E-1. Therefore, the preparation of water requires special attention by using reverse osmosis membranes. Prepared and purified water is mixed into an alkaline electrolyte located in the electrolysis system E-1, where, under the influence of direct current, it is split into two parts of hydrogen and one part of oxygen.
The source of hydrogen and oxygen in electrolysis units is demineralized and deeply purified water. The life of the entire hydrogen generation system depends on the quality of the water treatment. The salts contained in untreated industrial water very quickly destroy the electrodes in the electrolyzer E-1. Therefore, the preparation of water requires special attention by using reverse osmosis membranes. Prepared and purified water is mixed into an alkaline electrolyte located in the electrolysis system E-1, where, under the influence of direct current, it is split into two parts of hydrogen and one part of oxygen.
Advanatges of AGS Hydrogen Generators
1
Low power consumption - 5,1 kWh/Nm3
1
Load control from 0% to 100% - Fully automated control system
1
Quick start (within 10-20 seconds)
1
Corrosion-proof pipelines and designs
Additional options
DPM / DPH Finishing System
To achieve concentrations of production hydrogen or nitrogen above 99.9995% by burning oxygen on a palladium catalyst.
Additional drying system
Designed for deep purification of hydrogen from oxygen, moisture and impurities by its catalytic hydrogenation.
Gas mixing station
Designed for mixing two or three technical gases, equipped with inlet pressure control units and gas analyzers for continuous monitoring of the mixture composition.
1
Modular Air Cooling Units (MACU)
Closed system for cooling the electrolyte and gases (it is recommended to use instead of the usual water circuit).
Nitrogen station placement options
Monoblock version

To achieve concentrations of production hydrogen or nitrogen above 99.9995% by burning oxygen on a palladium catalyst.

Block container

Designed for mixing two or three technical gases, equipped with inlet pressure control units and gas analyzers for continuous monitoring of the mixture composition.

Supply Geography
1 1
IE Skiller
Omsk
Equipment supplied:
АВС-24К
Concentration: 95%
Productivity: 24 m3/h
1 1
PG "PHOSPHORIT"
Kingisepp
Equipment supplied:
Nitrogen station GB-1500
Concentration: 97%
Productivity: 1500 m3/h
1 1
TESTPRYBOR
Kazan
Equipment supplied:
Nitrogen AGS station
Concentration: 99.9995%
Productivity: 16 м3/ч m3/h
1 1
LLC "Evakem"
Kazan
Equipment supplied:
МАВС-5А
Concentration: 99,95%
Productivity: 6 m3/h
1 1
PJSC LUKOIL
Astrakhan
Equipment supplied:
МВС-5А
Concentration: 99%
Productivity: 5 m3/h
1 1
PAO Svetlana
St. Petersburg
Equipment supplied:
АВС-1600А
Concentration: 99,9995%
Productivity: 320 m3/h
1 1
Techmontazh
Omsk
Equipment supplied:
КВС-700А
Concentration: 99,9995%
Productivity: 700 m3/h
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
Implemented projects
Submit your inquiry
If you are interested in our equipment and you want to receive detailed information
Order a call back
Order a business proposal